bvorland
-
Innholdsteller
2 -
Ble med
-
Besøkte siden sist
Innlegg skrevet av bvorland
-
-
Hi Forum,
This is my first post so feel free to move it to the correct thread.
So the issue at hand is that the AC clutch will not engage, all the fans a blowing when running the test on the Auto HVAC module
I have changed the solenoid valve on the compressor, and filled with coolant and leak stop.
On the first run of VCDS there are some Intermittent error codes.
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-907-044.lbl
Part No SW: 1K0 907 044 DA HW: 1K0 907 044 DA
Component: ClimatronicPQ35 133 1213
Revision: 00133026 Serial number: 00000000000000
Shop #: WSC 00000 000 00000
VCID: 698FBB69357217C3E45-803C
3 Faults Found:
01809 - Actuating Motor for Temperature Flap; Left (V158)
000 - - - Intermittent
00898 - Control Circuit A/C compressor
010 - Open or Short to Plus - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
I have cleared the codes, and when I run the car and turn on the AC and at the same time check the values on the pressure, fan speed and it all looks good except for "Fresh Air Intake Temperature" there are no reading on that value, so could this be my issue?
I have read somewhere that all this sensor are in serial, so they all need to deliver value within scope or the AC will not start..
Ref:
Address 08: Auto HVAC (1K0 907 044 DA)
20:58:25 Group 001: General
0.0 Compressor Shut-Off Code
1500 /min Engine Speed
48.0 km/h Vehicle Speed
00:02 Standing Time
20:58:25 Group 002: Compressor
0.820 A Compressor Current (actual)
0.820 A Compressor Current (specified)
1900 /min Compressor Rotations
1.3 Nm Compressor Load
20:58:25 Group 004: Temperatures
16.5°C Outside Temp. Unfiltered
17.0°C Outside Temp. Regulation
- Fresh Air Intake Temperature
85.0°C Coolant Temperature
Hope you have some insight into this, my local car dealer has given up on the case, and with a 4-6 weeks waiting line on VW dealer I would like to resolve this before the summer set in.
br
Bjørn Atle
Nødmodus Audi A3 2011 1.6 TDI
i Audi
Skrevet
Jeg hadde samme problem, og har byttet ERG (mye jobb) kostet vel 2500 fra autoparts +toll. Men var nødt for å få kjørt regenerering av partikkel filer også før feilen ble rettet.
Nå er det bare en temperatursensor så slår ut fra tid til annen.